Saved Account Join
Two vehicles camped on a rocky point above a big lake, seen from the air, the first fall color in the trees.

The Overland Directory

Sprinter van builders in Ohio

Upfitters and conversion shops that turn an empty Mercedes-Benz Sprinter into a van you can live and travel in.

Get free quotes

Sprinter van builders in Ohio

2 listings

  1. Creative Mobile Interiors Grove City, OH Custom vehicle conversion shop that designs and builds adventure campers, motor homes, executive vans and mobile offices on Sprinter, bus and trailer shells.
  2. Advanced RV Willoughby, OH Builder of custom Class B motorhomes made to order on Mercedes-Benz Sprinter and Ford Transit chassis, with its own cabinetry and electrical systems and later servicing and updates.

Ohio by the numbers

Acres of federal land 1
305,753
1.2 percent of Ohio. The BLM manages none of it
Acres of national forest, all of it the Wayne 1
244,357
Ohio has one national forest. It describes itself as a patchwork of over a quarter million acres in three units
Federal campgrounds a vehicle can reach 2
6
Three at Lake Vesuvius in the Wayne, three at Corps of Engineers lakes. Four can be booked ahead
Acres in Cuyahoga Valley National Park 31
33,000
No entry gates and no fee. No camping is permitted anywhere in the park
State forests, covering more than 200,000 acres 17
24
The Division of Forestry runs four all-purpose vehicle areas on them
Miles of off-highway vehicle trail on the Wayne 8
145
The forest calls it the largest OHV trail system in Ohio. Its passes page says nearly 150 miles
Width limit on a state forest APV trail 19
62 in
The Wayne holds its trails to 50 inches. Neither figure describes a full-size truck
Campbell Hill, the highest point in Ohio 3
1,550 ft
Logan County. Our own 3DEP query at the summit reads 1,548 feet. The low point is about 455 feet on the Ohio River

Building a van for Ohio

A van works well in this state. Distances are short, towns are close, the byways are paved and the campgrounds that a van can reach are mostly developed: three at Lake Vesuvius, three on Corps of Engineers lakes, and the state forest and state park campgrounds beyond them. An Ohio state park site takes two vehicles, or one vehicle and one boat, which suits a van plus a trailer if you plan it.

Ask a builder about wet cold rather than deep cold. Ohio winters are chilly rather than bitter, but they are long and damp, and the state forest bridle trails and three of the four APV areas shut from December to April, so a van used through winter is mostly a road and campground vehicle. Ground clearance matters more than four-wheel drive on a soft spring forest road.

The full guide to overlanding Ohio

What a Sprinter builder does

A conversion is a small house on a moving, flexing, weight-limited platform. The builder insulates and lines the shell, installs the electrical system, plumbing, heat and ventilation, builds the bed, galley and storage, and cuts the holes for windows, fans and vents that you do not want to get wrong.

Some shops build complete vans to a set floor plan. Others build to order, and a few will take on partial work such as electrical only.

A typical conversion includes

  1. 01Insulation, wall and ceiling panels, and flooring
  2. 02House battery, alternator charging, solar, inverter and shore power
  3. 03Roof fan, heater, and sometimes air conditioning
  4. 04Fresh and gray water, a sink, and sometimes a shower and water heater
  5. 05Bed, galley, seating and storage
  6. 06Windows, racks, ladders, awnings and exterior lighting

How to choose a van builder

Floor plans are easy to fall for. The questions underneath them matter more.

  1. 01Decide between a shop's standard layout and a custom build. Standard layouts are faster, and the shop has already solved their problems.
  2. 02Ask what the finished van weighs with water and gear. Sprinters are sold in several gross weight ratings, and a heavy build on the lightest chassis leaves little margin.
  3. 03Ask how the electrical system is protected and documented, and whether the components can be serviced on the road.
  4. 04Ask how cabinetry is fastened to the van. Furniture that is only screwed to thin wall panels works loose on rough roads.
  5. 05Ask how added seats and seat belts are engineered and anchored if anyone rides behind the front row.
  6. 06Get the scope, price, payment schedule and delivery date in writing.

What to have ready before you ask for a quote

The van you order decides what can be built in it, so it helps to talk to a builder before you buy.

  1. 01Model year, 144 or 170 wheelbase, roof height, and two-wheel, all-wheel or four-wheel drive
  2. 02How many people sleep in it and how many ride in it
  3. 03The seasons and climates you travel in
  4. 04Whether you need to work from it
  5. 05What goes inside with you: bikes, boards, dogs
  6. 06A budget range and the date you want to be traveling

Questions people ask

Do I need to own the van before I contact a builder?

No. Many builders would rather talk first, because the wheelbase, roof height and drivetrain you order decide what can be built. Some shops can also source a van.

How long does a Sprinter conversion take?

A full custom build is usually measured in months, plus whatever wait the shop has before it can start. Standard layouts are quicker. Ask for both numbers.

Should I get the 144 or the 170 wheelbase?

The 144 is easier to park, turn and drive on tight roads. The 170 gives you room for a fixed bed and a real galley without compromise. Think about where you will actually drive it, then about how you want to live in it.

Can these builders work on a Ford Transit or Ram ProMaster?

Many do. If you are on another platform, say so in the form and we will look for shops with that experience.

How high is Ohio?

From Portsmouth at 534 feet to Campbell Hill at 1,550. Altitude decides what your engine, your brakes and your lungs have to work with, and how late in the year the passes open.

Towns

  1. Bellefontaine Logan County, at 1,245 feet the highest of the towns in this guide. Campbell Hill, the state high point at 1,550 feet, is just east of town. 1,245 ft
  2. Woodsfield Monroe County seat and the north end of the Covered Bridge Scenic Byway on SR 26. 1,204 ft
  3. Loudonville In the Mohican valley. Mohican-Memorial State Forest, the one state forest besides Maumee where snowmobiles may use designated trails, is a few miles south at Perrysville. 974 ft
  4. New Lexington Perry County seat, the nearest town of any size to the Perry State Forest APV area, which the Division of Forestry calls the most popular public riding area in Ohio. 956 ft
  5. New Straitsville In Perry County on SR 595. The New Straitsville OHV trailhead is two miles south, one of two on Monday Creek with loading ramps. 793 ft
  6. McArthur Vinton County seat on US 50. Gateway to Zaleski State Forest, the second largest, and its backpack camps. 763 ft
  7. Peninsula In the Cuyahoga Valley between Cleveland and Akron, inside the national park’s 33,000 acres and on the Ohio and Erie Canalway Byway. No camping anywhere in the park. 754 ft
  8. Logan On US 33 at the gateway to Hocking Hills. Hocking State Forest and the Hocking Hills Scenic Byway both leave town on state routes. 740 ft
  9. Athens Where US 33 meets US 50 on the edge of the Athens Unit. The Forest Service names it as one of three cities that make a good place to start or end a visit, for lodging and dining. 719 ft
  10. Jackson Jackson County seat, one of the four counties in the Ironton Ranger District, between the Pine Creek OHV system and Richland Furnace State Forest. 688 ft
  11. Swanton Northwest Ohio, southwest of Toledo. Maumee State Forest and its APV area, the only one of the four that stays open through winter. 684 ft
  12. Nelsonville On US 33 about 70 miles southeast of Columbus. Wayne National Forest headquarters, welcome center and the Athens Ranger Station. Monday Creek OHV trails start just north. 679 ft
  13. Chillicothe On US 23 and US 50. The Division of Forestry’s Chillicothe district office, and the way in to Scioto Trail and Tar Hollow state forests. 634 ft
  14. Marietta At the mouth of the Muskingum on the Ohio River. South end of the Covered Bridge Scenic Byway and home of the Wayne’s Marietta field office. 612 ft
  15. Ironton On US 52 at the Ohio River, at the edge of the Ironton Ranger District. Lake Vesuvius and its three campgrounds are 6.5 miles north on SR 93. 551 ft
  16. Portsmouth Where US 23 meets US 52. Shawnee State Forest, the largest in the state, starts just west on US 52. 534 ft

Passes, high roads and summits

  1. Campbell Hill The highest point in Ohio, in Logan County. Our own 3DEP reading at the USGS point is 1,548 feet 1,550 ft
  2. Mount Logan Ross County, above the Scioto valley at Chillicothe. Measured for this chart; no agency publishes a figure for it 1,246 ft

Pass, road and summit elevations are the figures published by the agency that manages them. Town elevations are the town’s or county’s own figure where it publishes an exact one; the rest are from the U.S. Geological Survey (3D Elevation Program at the place’s official coordinates), retrieved September 18, 2026. Every source is listed at the foot of the page.

Free build quotes

Looking for Sprinter van builders in Ohio? Tell us about the project and get free quotes.

Tell us about your project

Free build quotes

Tell us about your project

What are you building on?

Do you have it yet?

What do you want done?

Choose everything that applies.

What are you working with?

Budget for this work

When you want it done

A range is enough. It tells a builder which conversation to have with you.

Where should the shop be?

How far will you go for the right shop?

Where should the quotes go?

Best way to reach you

Free, and no obligation. We use these details only to connect you with builders. See our privacy page.

Sources for this page

35
  1. Congressional Research Service. Federal Land Ownership: Overview and Data (R42346), Tables 1 and 2, data as of September 30, 2024. Retrieved September 19, 2026.
  2. Recreation.gov. Recreation Information Database (RIDB) full export. Our count of federal campgrounds in Ohio a vehicle can reach. Retrieved September 19, 2026.
  3. U.S. Geological Survey. Elevations and Distances in the United States, online edition, Highest and Lowest Elevations table. Retrieved September 19, 2026.
  4. U.S. Geological Survey. Geographic Names Information System and 3D Elevation Program point query. Elevation of the 3DEP surface at the GNIS coordinates of the named place, rounded to the nearest foot. Retrieved September 19, 2026.
  5. USDA Forest Service, Wayne National Forest. Wayne National Forest home page. Retrieved September 19, 2026.
  6. USDA Forest Service, Wayne National Forest. About the Area: what to expect when visiting, and climate. Retrieved September 19, 2026.
  7. USDA Forest Service, Wayne National Forest. Recreation, including the 2026 Seasonal Recreation Dates. Retrieved September 19, 2026.
  8. USDA Forest Service, Wayne National Forest. Off-Highway Vehicles (OHV), including the 2026 trail systems and rules. Retrieved September 19, 2026.
  9. USDA Forest Service, Wayne National Forest. Passes and Permits: off-highway vehicle trail passes. Retrieved September 19, 2026.
  10. USDA Forest Service, Wayne National Forest. Motor Vehicle Use Maps, Athens, Ironton and Marietta units, 2026. Retrieved September 19, 2026.
  11. USDA Forest Service, Wayne National Forest. Forest-Wide Restriction: Occupancy and Use, Order 09-14-24-03, signed May 2, 2024. Retrieved September 19, 2026.
  12. USDA Forest Service, Wayne National Forest. Monday Creek OHV System. Retrieved September 19, 2026.
  13. USDA Forest Service, Wayne National Forest. Hanging Rock Recreation Area. Retrieved September 19, 2026.
  14. USDA Forest Service, Wayne National Forest. Pine Creek OHV System, with the Telegraph Trail closure order. Retrieved September 19, 2026.
  15. USDA Forest Service, Wayne National Forest. Covered Bridge Scenic Byway. Retrieved September 19, 2026.
  16. USDA Forest Service, Wayne National Forest. Lake Vesuvius Recreation Area. Retrieved September 19, 2026.
  17. Ohio Department of Natural Resources, Division of Forestry. Ohio State Forests Guide, brochure updated October 8, 2024. Retrieved September 19, 2026.
  18. Ohio Department of Natural Resources. Division of Forestry: state forest camping reservations, seasonal bridle trail closure and APV trail notices. Retrieved September 19, 2026.
  19. Ohio Department of Natural Resources, Division of Forestry. APV Trails in State Forests, quoting OAC 1501:3-4-15 and ORC 4519.09 and 4519.11. Retrieved September 19, 2026.
  20. Ohio Department of Natural Resources. Perry State Forest. Retrieved September 19, 2026.
  21. Ohio Department of Natural Resources. Pike State Forest. Retrieved September 19, 2026.
  22. Ohio Department of Natural Resources. Richland Furnace State Forest. Retrieved September 19, 2026.
  23. Ohio Department of Natural Resources. Maumee State Forest. Retrieved September 19, 2026.
  24. Ohio Department of Natural Resources. State Park Rules: Activities Not Allowed at Ohio State Parks, and Camping Rules for Ohio State Parks (OAC 1501:46-3 and 1501:46-9). Retrieved September 19, 2026.
  25. Ohio Department of Natural Resources, Division of Forestry. Open Burning Regulations, citing Ohio Revised Code 1503.18. Retrieved September 19, 2026.
  26. Ohio Bureau of Motor Vehicles. New Vehicle Registration: All-Purpose Vehicles (APV), Off-Highway Motorcycles, and Snowmobiles, citing ORC 4503.37. Retrieved September 19, 2026.
  27. Ohio Department of Transportation. Snow and Ice: winter maintenance responsibility. Retrieved September 19, 2026.
  28. Ohio Department of Transportation. Ohio Byways: Ohio River Scenic Byway. Retrieved September 19, 2026.
  29. Ohio Department of Transportation. Ohio Byways: Hocking Hills Scenic Byway. Retrieved September 19, 2026.
  30. Ohio Department of Transportation. Ohio Byways: Ohio and Erie Canalway Byway. Retrieved September 19, 2026.
  31. National Park Service, Cuyahoga Valley National Park. Frequently Asked Questions. Retrieved September 19, 2026.
  32. National Park Service, Cuyahoga Valley National Park. Camping. Retrieved September 19, 2026.
  33. U.S. Fish and Wildlife Service. Ottawa National Wildlife Refuge. Retrieved September 19, 2026.
  34. U.S. Army Corps of Engineers. Corps Lakes Gateway: Ohio. Retrieved September 19, 2026.
  35. Office of the Federal Register. 36 CFR 327.7, Camping (Corps of Engineers water resources development projects). Retrieved September 19, 2026.

Reviewed September 19, 2026. Conditions, closures and rules change; check with the managing agency before you travel.

More in Ohio

Keep going

Join Overlanding Life
Saved Account

Start with a region

Browse the directory