Sipsey in the Bankhead, Cheaha and Dugger Mountain in the Talladega, designated between 1977 and 1999. Motors and mechanised equipment are barred from all three
Two All-American Roads, the Natchez Trace Parkway and the Selma to Montgomery March Byway, and two National Scenic Byways, the Talladega Scenic Drive and Alabama’s Coastal Connection
Scenic drive the Forest Service publishes for the state 22
1
The Talladega Scenic Drive is the only named driving route across all four Alabama national forests. Everything else is an unnamed forest road on a motor vehicle use map
The Talladega Scenic Drive, as FHWA measures it 33
26.4 mi
The Forest Service gives the same byway as 29 miles. FHWA allows an hour for it and charges a dollar a person for the side trip into Cheaha State Park
Of Pinhoti National Recreation Trail in the Talladega 23
140 mi
Piedmont to Sylacauga, in the forest’s own Talladega handout. The same forest’s wilderness page calls it 100 miles of moderate to difficult hiking. It is a walking trail, not a driving one
Combined length of the Black Warrior and Tombigbee lakes 35
457 mi
Six lakes, Demopolis, Coffeeville, Warrior, Oliver, Holt and Bankhead, and 39,800 surface acres of water, all of it Mobile District
Approximately, on the coast beside Gulf State Park and the Coastal Connection byway. No vehicle may be driven on the sand anywhere along it
What Alabama asks of a build
Altitude is not the brief here. The towns in this guide run from seven feet at Gulf Shores to 960 at Heflin. What Alabama tests is water and clay. The state climatologist records 56.88 inches of rain a year, and the Forest Service answers it by telling visitors to stay off unpaved roads when they are wet or muddy.
Width is the second decision and it is binary. A full-size truck is welcome on every open forest road, every Corps lake camp and all four byways, and too wide for Flint Creek at 50 inches. Decide early whether you are building the road vehicle or towing the trail machine.
A builder plans and installs the whole system rather than one part of it: suspension matched to the finished weight, protection where the vehicle actually touches the ground, electrical power sized to what you run, and storage, water, sleeping and recovery points that work together. The good ones start with how you travel and work backward to parts.
The work that matters most is the work you cannot see. Wiring that is fused, labeled and documented. Fasteners that stay tight on washboard. A finished weight that stays inside what the vehicle is rated to carry.
Most full builds cover
01Suspension and tires chosen for the loaded weight
02Bumpers, sliders, skid plates and rated recovery points
03House battery, charging, solar and lighting
04Storage, drawers, fridge and water
05Sleeping: a roof tent, a camper or an interior platform
06Mounts for communications and navigation
How to choose a builder
Any shop can show you a finished truck in good light. These questions tell you how it was built.
01Ask to see finished builds on your platform, and talk to an owner who has put miles on one if you can.
02Ask what the vehicle will weigh when it is done and how that compares to its gross vehicle weight rating. A builder who cannot answer has not done the math.
03Ask who does the electrical work and whether you get a wiring diagram at handover.
04Ask what is done in house and what is sent out.
05Get the scope, the parts list, the price and the payment schedule in writing before work starts, and ask how changes are handled.
06Ask what warranty covers their labor, separate from the manufacturers' warranties on parts.
What to have ready before you ask for a quote
A builder can only quote what you can describe. The form on this page asks for exactly these things, which is why a quote that comes back from it is worth something.
01Year, model, engine and drivetrain, and for vans the wheelbase and roof height
02What has already been done to it
03How you travel: weekends or months, how many people, which climates, how far from pavement
04What you need to carry: water, fuel, bikes, boats, tools
05A budget range and a date you would like it back
Questions people ask
How much does an overland build cost?
It depends on scope more than on the vehicle. Suspension, tires and a roof tent is a different project from a full electrical system with cabinetry and armor, and labor is usually the largest part of a full build. The only number worth planning around is a written quote against a defined scope, which is what the form on this page is for.
How long does a build take?
Bolt-on work can be days. Full builds take longer, and at busy shops the wait for a start date can be longer than the work itself. Ask every shop for both numbers: when they can start and how long they need the vehicle.
Should I build in stages or all at once?
Stages work if the order is right. Decide the finished load first, because springs chosen for an empty truck will be wrong for a full one. Run electrical before interiors go in, because pulling cabinets to add a wire is paying for the same work twice.
Will modifications affect my warranty or insurance?
They can. Ask the builder which work they have seen raise warranty questions on your platform, read your warranty terms, and tell your insurer what has been added so the build is covered for its real value.
How high is Alabama?
From Gulf Shores at 7 feet to Cheaha Mountain at 2,407.
Altitude decides what your engine, your brakes and your lungs have to work with, and how late in the year the passes open.
02,000
Feet above sea level
Towns
HeflinCleburne County seat at 960 feet on US 78 and Interstate 20. The Shoal Creek Ranger District office is here, and the Talladega Scenic Drive leaves State Route 281 just west of town.960 ft
Fort PayneDeKalb County seat at 905 feet under Lookout Mountain. DeSoto State Park is eight miles northeast and the Little River Canyon Rim Parkway runs south from the falls.905 ft
Double SpringsWinston County seat and the Bankhead Ranger District office on Highway 33. Flint Creek, one of the state’s two OHV trails, is run from here.824 ft
AnnistonCalhoun County seat between the Shoal Creek and Talladega districts. The largest services stop within reach of Dugger Mountain, Choccolocco and the northern Pinhoti.711 ft
GuntersvilleMarshall County seat at 637 feet on the Tennessee River. Lake Guntersville State Park covers 6,000 acres of woodland above town with 36 miles of trail.637 ft
TalladegaTalladega Ranger District office, and the way up to Lake Chinnabee, Turnipseed and the Kentuck trail. Last town of any size on the west side of the Cheaha high ground.555 ft
FlorenceLauderdale County on the north bank of the Tennessee River. The Natchez Trace Parkway crosses this county between mileposts 328 and 342 before it leaves for Tennessee.550 ft
TuscumbiaColbert County seat south of the river. The parkway runs the length of this county from milepost 309 to 328, with the Colbert Ferry site on the Tennessee River at 327.3.468 ft
TuskegeeMacon County seat beside the smallest national forest in the country, which allows primitive camping anywhere outside gun deer season. Taska Recreation Area is 3.5 miles east on US 80 and 29.462 ft
AndalusiaCovington County seat and the Conecuh Ranger District office on Alabama Highway 55. Fuel and tyres before Open Pond, Blue Lake and the Florida line.345 ft
EufaulaBarbour County on the Chattahoochee, beside Walter F. George Lake and its 640 miles of shoreline, 13 Corps day use parks and four campgrounds.263 ft
BrentBibb County, and the Oakmulgee Ranger District office on Highway 5. The way in to Payne Lake, the Vick and South Sandy ranges and the district’s ten year-round hunting camps.241 ft
MontgomeryThe Forest Service supervisor’s office for all four Alabama national forests is on Chestnut Street. East end of the Selma to Montgomery March Byway and the nearest city to Horseshoe Bend.238 ft
SelmaDallas County seat at 137 feet on the Alabama River. West end of the 54-mile All-American Road to Montgomery, and close to the Corps lakes on the middle river.137 ft
DemopolisMarengo County, where the Tombigbee meets the Black Warrior. Corps resource manager’s office two miles west on US 80, and the south end of the Tennessee-Tombigbee river section.125 ft
Gulf ShoresSeven feet above the Gulf. Gulf State Park and its 496 improved campsites, the east end of Alabama’s Coastal Connection, and a city ordinance that bans every motor vehicle from the sand.7 ft
Passes, high roads and summits
Cheaha MountainTalladega Scenic Drive: US 78 west of Heflin to Adams Gap, on State Route 2812,407 ft
Dugger MountainCalhoun County, in the Dugger Mountain Wilderness on the Shoal Creek district. Measured for this chart from the 3DEP surface; no agency publishes a figure for it2,134 ft
Monte Sano MountainMadison County above Huntsville, the north end of the same ridge country. Our own 3DEP reading, not an agency figure1,654 ft
Adams GapClay County, where the pavement of the Talladega Scenic Drive ends and Forest Service Road 600 begins. Our own 3DEP reading1,443 ft
Pass, road and summit elevations are the figures published by the agency that manages them. Town elevations are the town’s or county’s own
figure where it publishes an exact one; the rest are from the U.S. Geological Survey (3D Elevation Program at the place’s official coordinates),
retrieved September 18, 2026. Every source is listed at the foot of the page.
Free build quotes
Looking for overland builders in Alabama? Tell us about the project and get free quotes.
