120 Forest Service, 44 BLM and 15 National Park Service. 122 take reservations
Winter winds the State Climate Office calls frequent 5
30 to 40 mph
With gusts to 50 or 60
What Wyoming asks of a build
Build for distance and wind before you build for rock. Wyoming has fewer people than any other state, and its signature drives are long graded roads: 102 miles around the South Bighorn/Red Wall byway and 64 from Seminoe to Alcova, neither with fuel along the way. Tell a builder that range, a full-size spare and room for water matter more here than articulation.
Then think about height. The State Climate Office describes frequent winter winds of 30 to 40 miles per hour with gusts to 50 or 60, and everything on the roof meets them. In bear country a closed, hard-sided vehicle is also a legal place to store food.
A builder plans and installs the whole system rather than one part of it: suspension matched to the finished weight, protection where the vehicle actually touches the ground, electrical power sized to what you run, and storage, water, sleeping and recovery points that work together. The good ones start with how you travel and work backward to parts.
The work that matters most is the work you cannot see. Wiring that is fused, labeled and documented. Fasteners that stay tight on washboard. A finished weight that stays inside what the vehicle is rated to carry.
Most full builds cover
01Suspension and tires chosen for the loaded weight
02Bumpers, sliders, skid plates and rated recovery points
03House battery, charging, solar and lighting
04Storage, drawers, fridge and water
05Sleeping: a roof tent, a camper or an interior platform
06Mounts for communications and navigation
How to choose a builder
Any shop can show you a finished truck in good light. These questions tell you how it was built.
01Ask to see finished builds on your platform, and talk to an owner who has put miles on one if you can.
02Ask what the vehicle will weigh when it is done and how that compares to its gross vehicle weight rating. A builder who cannot answer has not done the math.
03Ask who does the electrical work and whether you get a wiring diagram at handover.
04Ask what is done in house and what is sent out.
05Get the scope, the parts list, the price and the payment schedule in writing before work starts, and ask how changes are handled.
06Ask what warranty covers their labor, separate from the manufacturers' warranties on parts.
What to have ready before you ask for a quote
A builder can only quote what you can describe. The form on this page asks for exactly these things, which is why a quote that comes back from it is worth something.
01Year, model, engine and drivetrain, and for vans the wheelbase and roof height
02What has already been done to it
03How you travel: weekends or months, how many people, which climates, how far from pavement
04What you need to carry: water, fuel, bikes, boats, tools
05A budget range and a date you would like it back
Questions people ask
How much does an overland build cost?
It depends on scope more than on the vehicle. Suspension, tires and a roof tent is a different project from a full electrical system with cabinetry and armor, and labor is usually the largest part of a full build. The only number worth planning around is a written quote against a defined scope, which is what the form on this page is for.
How long does a build take?
Bolt-on work can be days. Full builds take longer, and at busy shops the wait for a start date can be longer than the work itself. Ask every shop for both numbers: when they can start and how long they need the vehicle.
Should I build in stages or all at once?
Stages work if the order is right. Decide the finished load first, because springs chosen for an empty truck will be wrong for a full one. Run electrical before interiors go in, because pulling cabinets to add a wire is paying for the same work twice.
Will modifications affect my warranty or insurance?
They can. Ask the builder which work they have seen raise warranty questions on your platform, read your warranty terms, and tell your insurer what has been added so the build is covered for its real value.
How high is Wyoming?
From Sheridan at 3,748 feet to Gannett Peak at 13,804.
Altitude decides what your engine, your brakes and your lungs have to work with, and how late in the year the passes open.
2,0004,0006,0008,00010,00012,00014,000
Feet above sea level
Towns
PinedaleSouth end of the Wyoming Centennial Scenic Byway, on US 191 under the Wind River Range. BLM and Bridger-Teton offices.7,179 ft
LaramieOn I-80. Highway 130 runs 30 miles west to Centennial, where the Snowy Range Scenic Byway enters the forest.7,165 ft
KemmererBLM field office and a Bridger-Teton ranger district. The Big Spring Scenic Backway runs from here to Cokeville.6,955 ft
DuboisNorth end of the Wyoming Centennial Scenic Byway, on US 26/287 below Togwotee Pass. Shoshone National Forest district office.6,934 ft
RawlinsOn I-80. Its BLM field office manages the Seminoe to Alcova byway, which leaves the interstate at Sinclair, exit 219.6,796 ft
SaratogaWest end of the Snowy Range Scenic Byway. The Forest Service district office here covers the Sierra Madre and the west side of the Snowy Range.6,789 ft
Rock SpringsOn I-80 with a BLM field office. The road to the Killpecker Sand Dunes leaves US 191 to the north, and the BLM’s 24-mile Pilot Butte Wild Horse Scenic Tour starts here.6,388 ft
JacksonBase for Grand Teton. The highway north to Flagg Ranch is plowed all winter. The Forest Service says camping nearby often fills by late morning in summer.6,238 ft
CheyenneState capital, where I-25 crosses I-80. The BLM’s Wyoming State Office is here.6,092 ft
LanderAt the foot of the east slope of the Wind River Range. Shoshone National Forest district office and a BLM field office.5,356 ft
CasperBLM field office. The South Bighorn/Red Wall byway starts 13 miles northwest on US 20/26, and Alcova is 30 miles out on Highway 220.5,105 ft
CodyShoshone National Forest headquarters, about 50 miles from Yellowstone’s East Entrance. The Chief Joseph byway leaves Highway 120 sixteen miles north.5,000 ft
BuffaloEast end of the Cloud Peak Skyway, US 16, over Powder River Pass. Full services and a BLM field office.4,640 ft
WorlandHome of the BLM field office that manages Red Gulch/Alkali. Full services west of the Cloud Peak Skyway.4,065 ft
GreybullAll services for the Red Gulch/Alkali byway. The turnoff is 11 miles east on US 14.3,794 ft
SheridanFull services for the Big Horn Scenic Byway, US 14, which climbs west from Dayton to Granite Pass.3,748 ft
Passes, high roads and summits
Gannett PeakThe highest point in Wyoming, in the Wind River Range. No road to the top13,804 ft
Cloud PeakThe highest point in the Bighorn National Forest, by the forest’s figure13,167 ft
Medicine Bow PeakAbove Snowy Range Pass on Highway 13012,013 ft
Beartooth PassBeartooth Highway (US 212): Red Lodge, Montana, to Cooke City and Yellowstone’s Northeast Entrance, across the northwest corner of Wyoming10,947 ft
Snowy Range PassSnowy Range Scenic Byway (WYO 130): Centennial to Saratoga, across the Medicine Bow Mountains10,847 ft
Powder River PassCloud Peak Skyway (US 16): Buffalo to Ten Sleep, across the southern Bighorns9,666 ft
Togwotee PassUS 26/287 between Dubois and Moran Junction, on the Wyoming Centennial Scenic Byway9,658 ft
Granite PassTop of the Big Horn Scenic Byway, US 14 between Shell and Dayton9,033 ft
Pass, road and summit elevations are the figures published by the agency that manages them. Town elevations are the town’s or county’s own
figure where it publishes an exact one; the rest are from the U.S. Geological Survey (3D Elevation Program at the place’s official coordinates),
retrieved September 18, 2026. Every source is listed at the foot of the page.
Free build quotes
Looking for overland builders in Wyoming? Tell us about the project and get free quotes.
