Arches, Bryce Canyon, Canyonlands, Capitol Reef and Zion. The Park Service counts 13 units in Utah and 14,354,141 visits to its national parks
What Utah asks of a build
Utah rewards a vehicle that is capable and small. The Park Service requires high clearance, four-wheel drive and low range on the White Rim Road and everywhere in the Maze, then caps Elephant Hill at 21 feet long and 85 inches wide. Tell a builder those numbers first, because a wide bumper or a long rack closes the best roads in the state to you.
After that it is heat, dust and distance. Towns run from 2,696 feet at St. George to 7,068 at Monticello, summer days pass 100°F in the south, and the nearest services to Hans Flat are 61 miles away in Hanksville.
A builder plans and installs the whole system rather than one part of it: suspension matched to the finished weight, protection where the vehicle actually touches the ground, electrical power sized to what you run, and storage, water, sleeping and recovery points that work together. The good ones start with how you travel and work backward to parts.
The work that matters most is the work you cannot see. Wiring that is fused, labeled and documented. Fasteners that stay tight on washboard. A finished weight that stays inside what the vehicle is rated to carry.
Most full builds cover
01Suspension and tires chosen for the loaded weight
02Bumpers, sliders, skid plates and rated recovery points
03House battery, charging, solar and lighting
04Storage, drawers, fridge and water
05Sleeping: a roof tent, a camper or an interior platform
06Mounts for communications and navigation
How to choose a builder
Any shop can show you a finished truck in good light. These questions tell you how it was built.
01Ask to see finished builds on your platform, and talk to an owner who has put miles on one if you can.
02Ask what the vehicle will weigh when it is done and how that compares to its gross vehicle weight rating. A builder who cannot answer has not done the math.
03Ask who does the electrical work and whether you get a wiring diagram at handover.
04Ask what is done in house and what is sent out.
05Get the scope, the parts list, the price and the payment schedule in writing before work starts, and ask how changes are handled.
06Ask what warranty covers their labor, separate from the manufacturers' warranties on parts.
What to have ready before you ask for a quote
A builder can only quote what you can describe. The form on this page asks for exactly these things, which is why a quote that comes back from it is worth something.
01Year, model, engine and drivetrain, and for vans the wheelbase and roof height
02What has already been done to it
03How you travel: weekends or months, how many people, which climates, how far from pavement
04What you need to carry: water, fuel, bikes, boats, tools
05A budget range and a date you would like it back
Questions people ask
How much does an overland build cost?
It depends on scope more than on the vehicle. Suspension, tires and a roof tent is a different project from a full electrical system with cabinetry and armor, and labor is usually the largest part of a full build. The only number worth planning around is a written quote against a defined scope, which is what the form on this page is for.
How long does a build take?
Bolt-on work can be days. Full builds take longer, and at busy shops the wait for a start date can be longer than the work itself. Ask every shop for both numbers: when they can start and how long they need the vehicle.
Should I build in stages or all at once?
Stages work if the order is right. Decide the finished load first, because springs chosen for an empty truck will be wrong for a full one. Run electrical before interiors go in, because pulling cabinets to add a wire is paying for the same work twice.
Will modifications affect my warranty or insurance?
They can. Ask the builder which work they have seen raise warranty questions on your platform, read your warranty terms, and tell your insurer what has been added so the build is covered for its real value.
How high is Utah?
From St. George at 2,696 feet to Kings Peak at 13,528.
Altitude decides what your engine, your brakes and your lungs have to work with, and how late in the year the passes open.
2,0004,0006,0008,00010,00012,00014,000
Feet above sea level
Towns
MonticelloWhere US 191 meets US 491. BLM Monticello Field Office and a Manti-La Sal ranger district. Nearest services to the Needles, 48 miles away.7,068 ft
TorreyOn Highway 24 at the west end of Capitol Reef, where Highway 12 comes over Boulder Mountain. The park’s visitor center and the Cathedral Valley turnoffs are just east.6,841 ft
BoulderOn Highway 12 at the west end of the Burr Trail, which is paved from here to the Capitol Reef boundary and graded dirt after it.6,704 ft
BlandingOn US 191 where Highway 95 heads west. The Park Service puts Natural Bridges and Hovenweep here, and the BLM puts Kane Gulch, the Cedar Mesa permit station, 36 miles away.6,104 ft
Cedar CityOn I-15, with Cedar Breaks National Monument in the mountains above. BLM Color Country District and the Dixie National Forest supervisor’s office.5,845 ft
EscalanteOn Highway 12 in Grand Staircase-Escalante. The Hole-in-the-Rock Road starts here and runs 62 miles southeast; a Dixie ranger district and the interagency visitor center are in town.5,813 ft
PriceOn US 6 with the BLM Price Field Office and the Manti-La Sal supervisor’s office. Nine Mile Canyon leaves from Wellington, just southeast, and the San Rafael Swell is south.5,561 ft
VernalOn US 40 in the northeast. Ashley National Forest headquarters and BLM Green River District, with Flaming Gorge and Dinosaur to the north and east.5,332 ft
KanabOn US 89 in the far south. BLM Paria River District and the Grand Staircase-Escalante office, which runs the Coyote Buttes and Paria Canyon permits. The Cottonwood Canyons backway meets US 89 about 64 miles east.4,970 ft
BluffOn US 191 above the San Juan River. The BLM’s Sand Island recreation area, with a campground and a boat ramp, is just outside town, and Valley of the Gods is 15 miles west.4,325 ft
HanksvilleHome of the BLM’s Henry Mountains Field Station, with the Bull Creek Pass byway leaving Highway 95 about 21 miles south. Nearest services to Hans Flat and the Maze, 61 miles away.4,303 ft
Salt Lake CityWhere I-15 meets I-80. BLM Utah state office and West Desert District, and the city below Big and Little Cottonwood Canyons, where the traction law is strictest.4,264 ft
Mexican HatWhere US 163 meets Highway 261 below the Moki Dugway. The east end of the Valley of the Gods road is seven miles away.4,253 ft
Green RiverWhere US 6 leaves I-70. The BLM sends San Rafael Swell visitors west from here, and the Park Service puts Hans Flat 84 miles away.4,070 ft
MoabOn US 191 between Arches and Canyonlands. BLM Canyon Country District and Moab Field Office, and the nearest services to Island in the Sky, 32 miles away.4,032 ft
St. GeorgeOn I-15 in the southwest corner, the lowest of these towns. A BLM field office and a Dixie ranger district; the Smithsonian Butte byway is east, below Zion.2,696 ft
Passes, high roads and summits
Kings PeakThe highest point in Utah, in the High Uintas Wilderness. No road to it13,528 ft
Blue Bell KnollThe high point of the Dixie National Forest, on Boulder Mountain above Highway 1211,322 ft
Bald Mountain PassThe high point of the paved Mirror Lake Scenic Byway, in the Uintas10,715 ft
Bull Creek PassBull Creek Pass Back Country Byway: A loop through the Henry Mountains, between Capitol Reef and Canyonlands. It leaves Highway 95 about 21 miles south of Hanksville10,478 ft
Pass, road and summit elevations are the figures published by the agency that manages them. Town elevations are the town’s or county’s own
figure where it publishes an exact one; the rest are from the U.S. Geological Survey (3D Elevation Program at the place’s official coordinates),
retrieved September 18, 2026. Every source is listed at the foot of the page.
Free build quotes
Looking for overland builders in Utah? Tell us about the project and get free quotes.
