On the Towns and Union county line. Our own query of the USGS elevation surface at the summit reads 4,773. The low point is the Atlantic Ocean at sea level
Across 26 counties and four ranger districts, with approximately 850 miles of recreation trails. The CRS puts all Forest Service land in Georgia at 868,513 acres
The 1895 to 2020 average. Over 70 inches in the northeastern mountains and around 45 in the southeast. Yearly snowfall in the northern mountains averages 5 inches
Designated by the state transportation department. One of them, the Russell-Brasstown, also carries National Scenic Byway status, awarded June 15, 2000
Building a van for a wet state with narrow gates
Measure before you weld. Lake Conasauga caps recreational vehicles at 24 feet and Jacks River Fields limits road and campground access to vehicles under 24 feet, which rules out a long wheelbase van with a rear rack before it has left the driveway. The approach roads are gravel and one-lane in places, so mirrors and overhang matter more than ground clearance on most of them.
Then build for humidity. With 50.0 inches of rain a year statewide, ventilation, condensation control and a way to dry gear inside are the daily problems in Georgia. Deep cold insulation is a lesser worry: the northern mountains average just 5 inches of snow a year.
A conversion is a small house on a moving, flexing, weight-limited platform. The builder insulates and lines the shell, installs the electrical system, plumbing, heat and ventilation, builds the bed, galley and storage, and cuts the holes for windows, fans and vents that you do not want to get wrong.
Some shops build complete vans to a set floor plan. Others build to order, and a few will take on partial work such as electrical only.
A typical conversion includes
01Insulation, wall and ceiling panels, and flooring
02House battery, alternator charging, solar, inverter and shore power
03Roof fan, heater, and sometimes air conditioning
04Fresh and gray water, a sink, and sometimes a shower and water heater
05Bed, galley, seating and storage
06Windows, racks, ladders, awnings and exterior lighting
How to choose a van builder
Floor plans are easy to fall for. The questions underneath them matter more.
01Decide between a shop's standard layout and a custom build. Standard layouts are faster, and the shop has already solved their problems.
02Ask what the finished van weighs with water and gear. Sprinters are sold in several gross weight ratings, and a heavy build on the lightest chassis leaves little margin.
03Ask how the electrical system is protected and documented, and whether the components can be serviced on the road.
04Ask how cabinetry is fastened to the van. Furniture that is only screwed to thin wall panels works loose on rough roads.
05Ask how added seats and seat belts are engineered and anchored if anyone rides behind the front row.
06Get the scope, price, payment schedule and delivery date in writing.
What to have ready before you ask for a quote
The van you order decides what can be built in it, so it helps to talk to a builder before you buy.
01Model year, 144 or 170 wheelbase, roof height, and two-wheel, all-wheel or four-wheel drive
02How many people sleep in it and how many ride in it
03The seasons and climates you travel in
04Whether you need to work from it
05What goes inside with you: bikes, boards, dogs
06A budget range and the date you want to be traveling
Questions people ask
Do I need to own the van before I contact a builder?
No. Many builders would rather talk first, because the wheelbase, roof height and drivetrain you order decide what can be built. Some shops can also source a van.
How long does a Sprinter conversion take?
A full custom build is usually measured in months, plus whatever wait the shop has before it can start. Standard layouts are quicker. Ask for both numbers.
Should I get the 144 or the 170 wheelbase?
The 144 is easier to park, turn and drive on tight roads. The 170 gives you room for a fixed bed and a real galley without compromise. Think about where you will actually drive it, then about how you want to live in it.
Can these builders work on a Ford Transit or Ram ProMaster?
Many do. If you are on another platform, say so in the form and we will look for shops with that experience.
How high is Georgia?
From Saint Marys at 10 feet to Brasstown Bald at 4,784.
Altitude decides what your engine, your brakes and your lungs have to work with, and how late in the year the passes open.
02,0004,0006,000
Feet above sea level
Towns
SuchesA settlement at 2,796 feet where GA 60 and GA 180 cross, ringed by national forest, with Deep Hole and the Toccoa River a few miles off.2,796 ft
HiawasseeTowns County seat on US 76 beside Lake Chatuge. The GA Spur 180 turn to the Brasstown Bald parking lot is southwest of town.1,969 ft
ClaytonRabun County seat where US 76 crosses US 441, in the county that holds the Chattooga Wild and Scenic River, Rabun Bald and the Oakey Mountain trails.1,933 ft
BlairsvilleUnion County seat where US 76 meets US 19 and 129. Blue Ridge Ranger District office, Beasley Knob two miles east, Brasstown Bald to the southeast.1,891 ft
Blue RidgeFannin County seat on GA 515. The only approach to Jacks River Fields from January through March, and the town beside Lake Blue Ridge.1,765 ft
ClevelandWhite County seat on US 129. The Chattahoochee Wildlife Management Area check station is about eight miles north by US 129 and GA 75 Alternate.1,569 ft
DahlonegaWhere GA 60 and US 19 start climbing into the Blue Ridge. The road to Woody Gap, Dockery Lake and the Whissenhunt trails leaves from here.1,454 ft
HelenOn GA 75 in the upper Chattahoochee valley, at the eastern end of the Russell-Brasstown byway below Unicoi Gap and Anna Ruby Falls.1,443 ft
EllijayGilmer County seat where GA 52 meets GA 515. The Gates Chapel Road approach onto Forest Road 90 and Forest Road 68 starts here.1,283 ft
GainesvilleSupervisor’s office for the Chattahoochee-Oconee National Forest, on Lake Lanier, and the last full-size service town before the mountains.1,242 ft
LaFayetteWalker County seat on US 27 in the Armuchee country, near the Ridge and Valley byway, Johns Mountain and Keown Falls.823 ft
DaltonOn I-75 in the Great Valley. Houston Valley, the largest Forest Service off-highway vehicle system in Georgia, lies just west of town.761 ft
ChatsworthMurray County seat on US 411 under the Cohutta front. Conasauga Ranger District office, and the bottom of the gravel road to Lake Conasauga.746 ft
EatontonPutnam County seat between Lake Oconee and Lake Sinclair, and the Oconee Ranger District office about 60 miles southeast of Atlanta.568 ft
FolkstonCharlton County town on US 1, the last services before the Suwannee Canal entrance to the Okefenokee and Swamp Island Drive.79 ft
Saint MarysEnd of GA 40 off I-95 and the mainland dock for the Cumberland Island ferry. Vehicles stay parked on this side of the sound.10 ft
Passes, high roads and summits
Brasstown BaldBrasstown Bald Spur (GA Spur 180): GA 180 to the Brasstown Bald parking lot4,784 ft
Rabun BaldRabun County, near the Carolina line. Our own measurement at the USGS point, not an agency figure4,697 ft
Blood MountainUnion County, above Neel Gap. State Parks calls it the highest summit on the Appalachian Trail in Georgia. Our own measurement at the USGS point4,454 ft
Tray MountainTowns County. Anna Ruby Falls drops 153 feet off its flank. Our own measurement at the USGS point4,422 ft
Springer MountainFannin County, southern end of the Appalachian Trail. Our own measurement at the USGS point3,780 ft
Grassy MountainOld CCC Camp Road, Forest Road 18 and Forest Road 68 to Lake Conasauga: Eton on US 411 to Lake Conasauga, or Gates Chapel Road and Forest Road 90 from Ellijay3,688 ft
Black Rock MountainBlack Rock Mountain State Park road: US 441 at Mountain City up to the summit visitor centre in Rabun County3,640 ft
Hogpen GapRussell-Brasstown Scenic Byway: A loop on GA 75 Alternate, GA 180, GA 348 and GA 17 and 75 north of Helen3,499 ft
Woody GapGA 60 and GA 180 through Suches: Dahlonega north over Woody Gap to Suches, then GA 180 east to US 19 and 1293,177 ft
Neel GapUS 19 and US 129 over Neel Gap: Cleveland and Dahlonega north to Blairsville, past Vogel State Park3,099 ft
Unicoi GapTowns County, where GA 75 crosses the Blue Ridge north of Helen. Our own measurement at the USGS point2,956 ft
Fort MountainCohutta-Chattahoochee Scenic Byway: Prater’s Mill in Whitfield County to a mountaintop overlook in Murray County, by GA 2, US 41 and GA 522,850 ft
Johns MountainRidge and Valley Scenic Byway: A loop on US 27, GA 156, GA 136 and rural county roads, reached from I-75 exits 306 and 3201,878 ft
Pass, road and summit elevations are the figures published by the agency that manages them. Town elevations are the town’s or county’s own
figure where it publishes an exact one; the rest are from the U.S. Geological Survey (3D Elevation Program at the place’s official coordinates),
retrieved September 18, 2026. Every source is listed at the foot of the page.
Free build quotes
Looking for Sprinter van builders in Georgia? Tell us about the project and get free quotes.
